The drain hoses are going thru the A-pillar and in the rear thru the C-pillar, here pics from an sliced E32 where you can see it
http://twrite.org/shogunnew/upgrades...nd_dicced_E32:
Note: the other pic links removed in 03/2024
Then there are drain holes in the area under the wiper motor area to drain off the water which comes thru the fresh air grills above the blower motor
http://i44.servimg.com/u/f44/14/94/56/00/ablauf10.jpg
One of the drain holes in the sunroof area
http://i64.servimg.com/u/f64/14/94/56/00/dsc01510.jpg
To check if the area under the doors in rocker panel area is full of water or if the drain holes are clogged, you can remove the door sill cover and check here with a flashlight
http://i34.servimg.com/u/f34/14/94/56/00/korros10.jpg
Sliced area to show where the drain hole ends in rocker panels right and left
http://s71.photobucket.com/albums/i1...fSchweller.jpg
Another thing to check the drain hole inside the e-box at the lowest point (where DME etc are located in engine room), there have been reports that these drain holes got clogged and expensive electronic devices like DME got damaged.
Drain from area where wiper motor is located, here the IHKA unit is also going thru the firewall into interior room, if these holes are clogged, you get water into the interior.
http://i44.servimg.com/u/f44/14/94/56/00/affnun10.jpg
Drain hose connections sunroof
http://bmwfans.info/parts/catalog/E3...ng_roof_drive/
The hole in the fiewall for IHKA and also the drain hole outside is shown here
http://www.bimmerboard.com/members/take/P1030372.jpg
rubber plugs in floor can slip out
http://www.bimmerboard.com/members/t...l/P1020853.jpg
here better to be seen, as well as one of the 2 drain holes for the IHKA under center console
http://www.bimmerboard.com/members/t...l/P1020855.jpg
holes towards engine room and the second drain hole IHKA seen from driver side.
http://www.bimmerboard.com/members/t...l/P1020859.jpg
If someone has more pics or hints where to check for clogged drain holes etc., please post them, then we have a detailed list.
In the trunk bottom on left side towards fender of my E32 are rubber flaps which lead the air from interior room thru the holes under the rear parcel shelf thru the trunk to the outside. Have no pics of these flaps.
Some pics are from E34, but basically the same.
Last edited by shogun; 03-16-2024 at 03:36 AM.
Shogun tricks and tips for the E32 series are HERE!
http://i71.photobucket.com/albums/i1...frontclip4.jpg I'm glad I finally have a picture of what you need to do, to be able to get to the heater box........when those flaps aren't working properly.
Last edited by shogun; 11-06-2019 at 09:42 AM.
One more possible leaking area, Water coming from e-box cooling fan into footwell
http://www.bimmerforums.com/forum/sh...ght=drain+hole
Shogun tricks and tips for the E32 series are HERE!
We need to store this pictures in a zip or on a google drive so that they do not go missing, this is valuable information.
Some good cut off sections from E34 where the drain hoses end , also how they modified the drain holes, from the German E34 forum https://forum.e34.de/thread.php?thre...ht=schiebedach
very long thread, go thru all pages and see for pics, they were posted over several years in this thread. Same design as on E32.
Here the pics of the modification on E34 with extended hoses going out of the sills , hope you can see the pics w/o being logged in/registered https://forum.e34.de/thread.php?thre...iebedachablauf
Last edited by shogun; 11-06-2019 at 09:45 AM.
Shogun tricks and tips for the E32 series are HERE!
1 more pic, water coming in thru the plastic covers under the windows into the area where the wiper motor/system is and the inlet flaps for the IHKA system, that is normal, water should then drain into the wheel wells of front fenders on each side, these small ports can clog, causing water to accumulate in that area and then enter thru the sealing of the IHKA housing in the firewall into the area where the IHKA is located behind the center console
Wasserablauf.jpg
better download all pics of interest, some links in the first posts are already no longer working. Photobucket, imageshack etc
Shogun tricks and tips for the E32 series are HERE!
Bookmarks