Kevlar
02-27-2001, 08:21 PM
<b>Engine Compartment </b>
<ul>
<li>Inspect Vbelt drive condition Check Tension</li>
<li> Lubricate Throttle Linkage</li>
<li> Replace air filter </li>
<li>Change Oil & Filter </li>
<li>Replace Spark Plugs </li>
<li>Check brake/clutch fluid level </li>
<li>Check battery acid level and correct </li>
<li>Check engine coolant level & anti-freeze protection. Check for leaks </li>
</ul>
<p><b>Under Car Maintenance</b>
<ul>
<li> Change auto tranny fluid </li>
<li>Change manual tranny oil </li>
<li>Check clutch plate for wear </li>
<li>Check drive axle boots for leaks </li>
<li>Change final drive fluid (1995 & later models: change synthetic oil every
2nd Inspection II) </li>
<li>Replace fuel filter </li>
<li>Inspect Exhaust System </li>
<li>Check steering gear and linkages. Check power steering system for leaks
Check fluid </li>
<li>Inspect brake system for damaged hoses, lines, leaks. </li>
<li>Remove calipers, check pad wear. Check rotors for scoring damage. </li>
<li>Check Parking Brake Operation, adjust cable if necessary. Check parking
brake linings </li>
<li>Inspect front/rear suspension, include wheel bearings for play. </li>
<li>Inspect wheels/tires/spare for correct tire pressure. </li>
</ul>
<p><b>Body & Interior Maintenance </b>
<ul>
<li>Lube door hinges, hood latch and hood hinges </li>
<li>Check headlight aiming, adjust if necessary </li>
<li>Check operation of headlights, parkign lights, back-up lights, interior
lights, glove box light, engine compartment light, trunk link, instrument
planel lights, turn signals, emergency flashers, stop lights, horns, headlight
flasher and dimmer switch Check active check control panel for faults </li>
<li>Replace AC microfilter. </li>
<li>Check AC system </li>
<li>Check seat belts </li>
<li>Check windshield washer fluid level and concentration. Check washer system
and wiper blades </li>
<li>Tighten nuts and bolts for door locks and striker plates.</li>
<li> Replace batteries for alarm/remote control in master key </li>
<li>Check ground connection of SRS front aribag </li>
</ul>
<p><b>Road Test</b>
<ul>
<li> Check brake performance, steering, HVAC, manual/auto tranny and mirrors
</li>
<li>Reset Service Lights</li>
</ul>
<ul>
<li>Inspect Vbelt drive condition Check Tension</li>
<li> Lubricate Throttle Linkage</li>
<li> Replace air filter </li>
<li>Change Oil & Filter </li>
<li>Replace Spark Plugs </li>
<li>Check brake/clutch fluid level </li>
<li>Check battery acid level and correct </li>
<li>Check engine coolant level & anti-freeze protection. Check for leaks </li>
</ul>
<p><b>Under Car Maintenance</b>
<ul>
<li> Change auto tranny fluid </li>
<li>Change manual tranny oil </li>
<li>Check clutch plate for wear </li>
<li>Check drive axle boots for leaks </li>
<li>Change final drive fluid (1995 & later models: change synthetic oil every
2nd Inspection II) </li>
<li>Replace fuel filter </li>
<li>Inspect Exhaust System </li>
<li>Check steering gear and linkages. Check power steering system for leaks
Check fluid </li>
<li>Inspect brake system for damaged hoses, lines, leaks. </li>
<li>Remove calipers, check pad wear. Check rotors for scoring damage. </li>
<li>Check Parking Brake Operation, adjust cable if necessary. Check parking
brake linings </li>
<li>Inspect front/rear suspension, include wheel bearings for play. </li>
<li>Inspect wheels/tires/spare for correct tire pressure. </li>
</ul>
<p><b>Body & Interior Maintenance </b>
<ul>
<li>Lube door hinges, hood latch and hood hinges </li>
<li>Check headlight aiming, adjust if necessary </li>
<li>Check operation of headlights, parkign lights, back-up lights, interior
lights, glove box light, engine compartment light, trunk link, instrument
planel lights, turn signals, emergency flashers, stop lights, horns, headlight
flasher and dimmer switch Check active check control panel for faults </li>
<li>Replace AC microfilter. </li>
<li>Check AC system </li>
<li>Check seat belts </li>
<li>Check windshield washer fluid level and concentration. Check washer system
and wiper blades </li>
<li>Tighten nuts and bolts for door locks and striker plates.</li>
<li> Replace batteries for alarm/remote control in master key </li>
<li>Check ground connection of SRS front aribag </li>
</ul>
<p><b>Road Test</b>
<ul>
<li> Check brake performance, steering, HVAC, manual/auto tranny and mirrors
</li>
<li>Reset Service Lights</li>
</ul>